MATERIAL SAFETY DATA SHEET
Essentially Similar to U.S. Department of Labor Form OSHA
Manufacturer:
A.V.W. Inc.
24-Hour
Transportation Emergency Phone Number: Chemtrac 800-424-9300 U.S. & Canada
Product
Name: Winchester Gun Wash
Composition
/ Information on Ingredient
Description Cas
Number
Weight Percent
Exposure
Limits
Trichloroethylene
79-01-6
97
50 ppm, OSHA
EMERGENCY OVERVIEV:
Clear, colorless liquid. Ether-like odor.
EYE CONTACT: May cause
mild eye irritation. Direct contact with the liquid or exposure to vapors or
mists may cause stinging, tearing and redness.
SKIN CONTACT:
Prolonged and repeated with skin can cause deflating and drying of the skin
which may result in skin irritation and dermatitis. May be harmful if absorbed
through skin.
INGESTION: Irritation
of mouth and throat. Aspiration into lungs may cause mild to severe pulmonary
injury.
INHALATION: High
concentrations or prolonged exposure to lower concentrations may be slightly
irritating to mucous membranes. Inhalation overexposure can lead to central
nervous system depression producing effects such as headaches, nausea,
dizziness and loss of consciousness. Extreme exposures may cause other central
nervous system effects including death.
CHRONIC: Not
established
EYE CONTACT:
Immediately flush eyes with plenty of water for at least 15 minutes. Hold
eyelids open during this flushing with water. Call a physician immediately.
SKIN CONTACT: Flush
Area with water while removing contaminated clothing and shoes. Follow by
washing with soap and water. Do not reuses clothing or shoes until cleaned. If
irritation persists, get medical attention. Do not apply oils or ointments
unless ordered by the physician.
INGESTION: If
conscious, drink a quart of water, then induce vomiting. CALL A PHYSICIAN
immediately. If unconscious or in convulsions, take immediately to a hospital
or to a physician. NEVER induce vomiting or give anything by mouth to an
unconscious victim.
INHALATION: Remove
victim to fresh air. If not breathing, give artificial respiration, preferably
mouth-to-mouth. If breathing is difficult, give oxygen. CALL A PHYSICIAN. Do
not give stimulants unless instructed to do so by a physician.
Flashpoint: None
Method Used:
FLAMMABLE LIMITS:
LFL: 8.0
UFL: 10.5
EXTINGUISHING
MEDIA: Dry chemical, CO2, water spray.
UNUSUAL
FIRE & EXPLOSION HAZARDS: Avoid possible bursting of aerosol can. Do not
store where temperature may exceed 120F. Do not puncture or incinerate. Product
may be thermally decompose to product Hydrogen Chloride vapors and possibly
traces of Phosgene. Concentrated vapors can be ignited by high intensity heat
source.
SPECIAL
FIRE FIGHTING PROCEDURES: Evacuate area of unprotected personnel. Wear
protective clothing including a NIOSH-Approved self-contained breathing
apparatus. Cool fire-exposed containers with water spray. Run-off from fire
control may cause pollution.
Accidental Release Measures
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
Review current local, state and federal
laws, codes, statutes, and regulations to determine appropriate agencies to be
notified, and the conditions under which they are to be notified. Eliminate
all sources of ignition. Evacuate unprotected personnel from area. Maintain
adequate ventilation. Use proper safety equipment. Contain spill, place into
drums for proper disposal. Soak up residue with non-flammable absorbent
material. Place in non-leaking containers for immediate disposal. Flush
remaining area with water to remove trace residue and dispose of properly.
Avoid direct discharge to sewers and surface waters. Notify authorities if
entry occurs.
WASTE DISPOSAL METHOD: Review current local, state and
federal laws, codes, statutes, and regulations to determine current status and
appropriate disposal method for the ingredients listed in Section 2. Dispose
of in accordance with all local, state and federal regulations. Dispose of at
approved Waste Treatment Facility. Reclaim (recycle) solvent DO NOT pressurize,
cut weld, braze, solder, drill, grind or exposure empty containers to heat,
flame, sparks or other sources of ignition.
Store in a cool, well-ventilated area away from all sources of ignition and out of direct sunlight. Ground all equipment to prevent accumulation of static charge. Keep containers tightly closed. Store away incompatible materials. Do not store in unlabeled or mislabeled containers.
Is
exceeded wear NIOSH-approved self-
conatained
breathing device or respirator.
LOCAL
EXHAUST VENTILATION (rate):
EYE PROTECTION: (type):
Safety glasses or
Must
be adequate to maintain vapors at less than
recommend.
50
ppm, particularly at floor level, as vapors are
heavier
than air.
MECHANICAL
VENTILATION (rate): None
OTHER PROTECTIVE EQUIPMENT: As needed
established minimize
contamination.
SPECIAL
VENTILATION: Do not use in small
enclosed
area.
BOILING
POINT: 188 degrees
SPECIFIC GRAVITY: 1.465
VAPOR
PRESSURE: 73mm Hg@68 degrees
VOLATILE BY VOLUME:
~97%
VAPOR
DENSITY: 4.54
EVAPORATION
RATE: 0.3 (Bu Ace=1)
SOLUBILITY
IN WATER: Slight
pH (100%) : NA
APPEARANCE
& ODOR: Clear, color liquid.
pH (10%) : NA
Ether
like odor
SECTION X
STABILITY:
Stable
CONDITIONS
TO AVOID: Avoid contact with heat, sparks, electric arcs, other hot surfaces
and open flames.
INCOMPATIBILITY
(materials to avoid): Strong oxidizing agents.
HAZARDOUS
DECOMPOSITION PRODUCTS: May thermally decompose to form Carbon Monoxide, Carbon
Dioxide, Hydrogen Chloride vapors, traces of Phosgene, and unidentifiable
materials.
HAZARDOUS
POLYMERIZATION: Will not occur.
CONDITIONS
TO AVOID: None known.
1.
Refer to Section 3 for available information on potential health
effects.
2. CALIFORNIA
PROPOSITION-65
WARNING: This product contains a
chemical known to the state of California to cause cancer.
This
product contains trichloroethylene that has been listed pursuant to Proposition
65, California Health & Safety
Code Section 25249.8. Employers may have obligation to warn their
employees and other on their premises of potential exposure to Proposition 65
listed substances. If this product is sold or used in or incorporated into a
product sold in California, California law may require that the manufacturer,
distributor and retailer of the product provide a warning pursuant to Proposition
65, California Health & Safety Code Section 25249.6. Failure to provide
required warning may result in legal liability. This product may no be
discharged onto land or into any source of drinking water in California.
Any
disposal practice must be in compliance with local, state, and federal laws and
regulations. Contact the appropriate agency for specific information.
Treatment, transport, storage and disposal of hazardous waste must be dealt
with must be dealt with by a licensed facility or waste hauler.
Transport
Information
D.O.T. HAZARDOUS MATERIALS
DESCRIPTION AND PROPER SHIPPING NAME:
Aerosols, non-flammable (not exceed 1 liter) Class 2.2/UN1950.
Exceptions
may apply: 49 CFR 173.306-307
ORM-D
Ground
transportation ONLY
DO
NOT SHIP TO CALIFORNIA
OSHA HAZARD COMMUNICATION RULE 29 CFR 1910.1000, Table Z-1A.
TSC
(TOXIC SUBSTANCES CONTROL ACT): the materials in this product are listed on the
TSCA Inventory.
CERCLA
(Comprehensive Response compensation and Liability Act, 40 CFR 302.4: Not
applicable.
SARA
TITLE III (Superfund Amendments and Authorization Act): 40 CFR 372.65.
CALIFORNIA
PROPOSITION 65:
WARNING: This product contains a chemical known to the State of
California to cause cancer.
This
product contains trichloroethylene that has been listed pursuant to Proposition
65, California Health & Safety Code Section 25249.8. Employers may have an obligation to
warn their employees and other on their premises of potential exposure to
Proposition 65 listed substances. If this product is sold or used in or
incorporated into a product sold in California, California law may require that
the manufacturer, distributor and retailer of the product provide required
warning might result in legal liability.
This product may not be discharged onto land or into any source of
drinking water in California.
Other
Information
NATIONAL FIRE PROTECTION ASSOCIATION CODES (NFPA):
HEALTH :2
FLAMMABILITY: 1
REACTIVITY: 0
HAZARDOUS MATERIAL
IDENTIFICATION SYSTEM (HMIS):
HEALTH: 3
FLAMMABILITY:1
REACTIVITY: 0
PERSONAL PROTECTION: C